描述

SEAGATE ST3630A

第一類故障點(也是故障最多的地點)在繼電器、接觸器。如該生產線PLC控制系統的日常維護中，電氣備件消耗量最大的為各類繼電器或空氣開關。主要原因除產品本身外，就是現場環境比較惡劣，接觸器觸點易打火或氧化，然后發熱變形直至不能使用。在該生產線上所有現場的控制箱都是選用密閉性較好的盤柜，其內部元器件較其他采用敞開式盤柜內元器件的使用壽命明顯要長。所以減少此類故障應盡量選用高性能繼電器，改善元器件使用環境，減少更換的頻率，以減少其對系統運行的影響。

第二類故障多發點在閥門或閘板這一類的設備上，因為這類設備的關鍵執行部位，相對的位移一般較大，或者要經過電氣轉換等幾個步驟才能完成閥門或閘板的位置轉換，或者利用電動執行機構推拉閥門或閘板的位置轉換，機械、電氣、液壓等各環節稍有不到位就會產生誤差或故障。長期使用缺乏維護，機械、電氣失靈是故障產生的主要原因，因此在系統運行時要加強對此類設備的巡檢，發現問題及時處理。我廠對此類設備建立了嚴格的點檢制度，經常檢查閥門是否變形，執行機構是否靈活可用，控制器是否有效等，很好地保證了整個控制系統的有效性。

第三類故障點可能發生在開關、極限位置、安全保護和現場操作上的一些元件或設備上，其原因可能是因為長期磨損，也可能是長期不用而銹蝕老化。如該生產線窯尾料球儲庫上的布料行走車來回移動頻繁，而且現場粉塵較大，所以接近開關觸點出現變形、氧化、粉塵堵塞等從而導致觸點接觸不好或機構動作不靈敏。對于這類設備故障的處理主要體現在定期維護，使設備時刻處于完好狀態。對于限位開關尤其是重型設備上的限位開關除了定期檢修外，還要在設計的過程中加入多重的保護措施。

第四類故障點可能發生在PLC系統中的子設備，如接線盒、線端子、螺栓螺母等處。這類故障產生的原因除了設備本身的制作工藝原因外還和安裝工藝有關，如有人認為電線和螺釘連接是壓的越緊越好，但在二次維修時很容易導致拆卸困難，大力拆卸時容易造成連接件及其附近部件的損害。長期的打火、銹蝕等也是造成故障的原因。根據工程經驗，這類故障一般是很難發現和維修的。所以在設備的安裝和維修中一定要按照安裝要求的安裝工藝進行，不留設備隱患。

第五類故障點是傳感器和儀表，這類故障在控制系統中一般反映在信號的不正常。這類設備安裝時信號線的屏蔽層應單端可靠接地，并盡量與動力電纜分開敷設，特別是高干擾的變頻器輸出電纜，而且要在PIC內部進行軟件濾波。這類故障的發現及處理也和日常點巡檢有關，發現問題應及時處理。

第六類故障主要是電源、地線和信號線的噪聲(干擾)，問題的解決或改善主要在于工程設計時的經驗和日常維護中的觀察分析。

要減小故障率，很重要的一點是要重視工廠工藝和安全操作規程在日常的工作中遵守工藝和安全操作規程，嚴格執行—些相關的規定，如保持集中控制室的環境等等，同時在生產中也要加強這些方面的霄理。

產品承諾：
保?證?全新原裝進口,
保?證?安全準時發貨，
保?證售后服務質量，
優勢價格，大量現貨。

主營DCS系統配件
機器人系統配件
大型伺服系統配件
品牌：ABB???,AB??,GE,FOXBORO,本特利，英維思，伍德沃德，西屋，瑞恩，施耐德，西門子，摩托羅拉，安川。力士樂。ACSO，橫河等進口品牌。Triconex?Siemens?Yaskawa?ABB?GE?Ovation?AB?Foxboro?Motorola?Schneider?XYCOM?KUKA

Parker Pressure Comp Flow Control 3000PSI # PCMS1600S

Parker Pressure Comp.Hydraulic Flow Control 3000PSI PCM

Parker Hydraulic Pump Pressure Comp Piston 32GPM P2075P

PARKER HYDRAULIC PRESSURE REDUCING VALVE~NEW~SURPL?US~

PARKER 422-8-RL MEDIUM PRESSURE HYDRAULIC HOSE 1/2″

PARKER PR3MM Pressure Reducing Valve

NEW PARKER R6PH PRESSURE CONTROL VALVE

3 Parker Low Pressure Regulators SQMICRO130E602P?FSMM

Parker Hydraulic Pressure/Temp CompFlow Control FG3PKCA

PRESSURE REDUCING GAUGE VERIFLO PARKER NPR73530W4PXFSM

Parker Proportional Pressure Valve NIB

New Overstock Parker A4ADB Pressure Regulator Valve

Parker Low Pressure Regulator SQ2MICRO0302PFS?MM New

NEW PARKER PRESSURE SWITCH SCPSD-250-04-17
With 90 warranty

Parker 240′ 1/2″ Low Pressure 250 PSI Rubber Hose 801-8

PARKER PRESSURE REGULATOR VALVE – REFRIGERATION

Parker RAS-600-S4 RAS600S4 RAS600S Pressure Valve NEW
One-day shipping available

Parker Hydraulic Pressure Compensated Flow Control

Parker RAS600S Pressure Control Valve RAS600S
One-day shipping available

Parker Flo Con SportII37 Refrigerant Pressure Regulator

Parker Flo Con SportII79 Refrigerant Pressure Regulator

Parker Flo ConSportII911 Refrigerant Pressure Regulator

Parker PRC3MM Pressure Control Valve Hydraulic
Expedited shipping available

8523 NEW Parker A4AD Pressure Regulator

Parker 214′ 1/2″ Low Pressure 250 PSI Rubber Hose 801-8

2658 NEW PARKER A4AD Refrigerant Pressure Regulator

Parker PR-1-4114-2 High Purity Pressure Regulator
One-day shipping available

PARKER PSB040AF1A HYDRAULIC PRESSURE SWITCH NIB

Parker PR-3-4118-1 ?” PTFE Pressure Regulator

Parker 959100W2PFSMM High Pressure Regulator NEW
One-day shipping available

PARKER PRESSURE DRIVER CARD 801179 **NICE**

PARKER PRM3AA25KNS 50 PRESSURE CONTROL VALVE New

Parker Hydraulic Pump Pressure Comp Piston 5GPM #PAV10

Parker BC10BMV 10 pressure control Valve NNB BC10BMV10

PARKER PRDM3PP02SVS PRESSURE REDUCING VALVE 315 BAR NEW

Parker Hydraulic Pump Pressure Comp Vane 45D10L1A1B1AC

Parker Veriflo Pressure Regulator
One-day shipping available

Parker 3000 PSI Hyd Pressure Cylinder 03.25JJ2HTS #6078

Parker Oildyne OE4-SBHS-5K Hydraulic Pressure Switch

Parker Convum MPS-R3F5-NC Stainless Pressure Sensor New
Expedited shipping available

PARKER A810E FLO-CON OUTLET PRESSURE REGULATOR 85272

New Parker Manapak Pressure Reducing Valve PRM3PA17KN32
One-day shipping available

PARKER REGULATOR BACK PRESSURE, BR-3-1168-2

Parker Low Pressure Regulator SQMICRO130E602P?FSMM New

Parker Low Pressure Regulator SMSQ2MICRO30102 New

Parker Hyd Pressure Reducing Valve PRDM2PP16SUS (NIB)

NEW PARKER VERIFLO DSG HP PRESSURE REDUCING REGULATOR

NEW, PARKER PRESSURE REDUCING VALVE PR800SM-20KE

Parker RAS-600-S4 RAS600S4 RAS600S Pressure Valve USED
One-day shipping available

Parker hydraulic pressure reducing valve FM3DDKN-50

Parker Hydraulic Pressure Reducing Valve

Parker Hydraulic Ring ASB250AF1A4 Pressure transducer

Parker Schrader Bellows Pressure Regulator 3568-2000

7134 NEW Parker A4A Pressure Regulator 1″

Parker Pressure Reducing Valve AR FM3DDKN 55

Parker Pressure Reducing Valve DR FM3DDKN 55

Parker 621B-6 Pressure Control Valve 621B6 USED
One-day shipping available

Parker PRDM2PP16SVG, Pressure Reducing Valve NEW

Parker PRDM2BB16LVM, Pressure Reducing Valve NEW

Parker PRDM2BB02LNM, Pressure Reducing Valve NEW

Parker PRDM2PP02LNM, Pressure Reducing Valve NEW

PARKER 626092 OILDYNE PRESSURE SWITCH 0E4-SBKS-44K NEW
Expedited shipping available

PARKER HYDRAULIC PRESSURE REDUCING VALVE PRDM2PP16LNS
Expedited shipping available

PARKER PRDM2PP16SVGX79?7 PRESSURE REDUCING VALVE NIB

PARKER HYDRAULIC PRESSURE REDUCING VALVE R6PM

PARKER MODEL A4A PRESSURE REGULATOR 2 1/2″ NEW

PARKER PRM3PP25K HYDRAULIC PRESSURE CONTROL VALVE

Parker Flo-Con By-Pass Pressure Regulator SM080128 NIB

Parker 41975 20-20 Clamp SAE flange high pressure

Parker Pressure Filter F3-15P-1-40SA-E?S-50-XX-11-80

Parker PRM3PAH-20GB Pressure Reducing Valve

Parker PR400SHV Pressure Reducing Valve

NOS! PARKER REMOTE PRESSURE AIR VALVE CWJ12501

NEW Parker Hydraulic Filter 932630Q High Pressure

Parker D39DW11C4N89 75, PRESSURE REGULATION VALVE , NEW

PARKER VERIFLO IR400S4PG PRESSURE REDUCING REGULATOR

NOS! PARKER REMOTE PRESSURE VALVE CC1225B

LOT PARKER VERIFLO PRESSURE TRANSDUCER SWITCH DWYER

Parker Oil Pressure Regulator Control Valve A4AL; *A7

Parker high pressure clamp flange elbow 41775-16-16

Parker 41575 16-16 Clamp SAE flange high pressure 1 in

Parker Pressure Regulator P3NRA1PBPP

Parker 035682000B Pressure Regulator

Parker Veriflo 944AOPLPNOSFSFF High Purity Low Pressure

PARKER HIGH PRESSURE BALL VALVE # BV3H06S2SS1N

PARKER 035662000B PRESSURE REGULATOR 5-125 PSIG NEW

Pressure Pump Inlet Filter **NEW** Part#1J2-5

Parker Flo-Con Pressure Regulator A7-A

PARKER H2 1/2″ SAFETY PRESSURE RELIEF VALVE REFRIGERANT

Parker 73212BN52N00 3/4″ Skinner Pressure Vessel 2-Way

Parker Scrader Bellows Pressure Regulator 035662000B

PARKER FP2AUS14 250 PRESSURE 1.000 STROKES AIR

Parker Veriflo IR4205 Stainless High Pressure Regulator

Parker Veriflo 1/4″ Pressure Regulator (SQ2MICRO130E60?)

PARKER REMOTE PRESSURE VALVE CC1225B 150 PSI DO 1/4″

Parker Pressure Regulator 72-130
Expedited shipping available

PARKER Flo-Con Pressure Regulator A8-AOE

5 PARKER SENSOCONTROL PRESSURE SWITCH SCPSD-600-04-07

3 NEW PARKER MANAPAK PRESSURE CONTROL VALVES PRM2PP07KN

LOT 2 PARKER PRESSURE REGULATOR MASTER PNEUMATIC FILTER

parker bvhp12bss1na HIGH PRESSURE BALL VALVE

Parker PRM3 PP17K Pressure Reducing Valve 150-2500 PSI

NEW PARKER FLO-CON BYPASS HOT GAS PRESSURE REGULATOR A9

PARKER/SCHRADER BELLOWS PRESSURE REGULATOR 035662000B

PARKER FLO-CON A7 PRESSURE REGULATOR 400 PSI
One-day shipping available

A810E Parker FLOCON 1-3/8″ Outlet Pressure Regulator
One-day shipping available

2683 NEW Parker 201673 Pressure Regulator

PARKER HYDRAULIC PRESSURE REDUCING VALVE V-21 FT

New Parker CPOM2AAV55X Pilot-Oper. Pressure Check Valve
Expedited shipping available

NIB PARKER BVHP16SSS1NA HIGH PRESSURE BALL VALVE
Expedited shipping available

Parker 035643000B Pressure Regulator NEW Free Shipping
One-day shipping available

Parker Hydr. Pressure Reducing Module D03 # BD03PNR-A

PARKER 1/4 NPT CONTROLLED PRESSURE SAFETY THUMB LEVER

Parker hydraulic cylinder model C2H19 PRESSURE 3000

New Parker 06E21A18AC Filter Regulator w/Pressure Gauge

Parker 3/8″ S. Air Dual Pressure Switch New

Parker Hannifin Hydraulic Pressure Control Valve 3000

Parker Pressure Switch Male DIN P01909

PRESSURE REDUCING RELIEF VALVE, PARKER #PR101S10-C3F

Parker SensoControl Senso Control SCP-8181 Pressure

NEW PARKER BI-PRESSURE PUMP CONTROL FPS-213

PARKER PRESSURE REDUCING HYDRAULIC VALVE PRM3PB25KN 32

PARKER PRESSURE REDUCING HYDRAULIC VALVE PRM3PAH-20HY

NEW PARKER VERIFLO IR501B6P0140458?0 PRESSURE REGULATOR

Parker grade 10 Hi pressure filter element 10CWC08-033

*NEW* Parker Senso Control Pressure Controller #SCPSD

Parker 1/2″ remote pressure valve SS121050 NIB
One-day shipping available

PARKER VERIFLO 43200648 PRESSURE TRANSDUCER

MAZAK PARKER PRESSURE REGULATOR UNIT

Parker Veriflo Pressure Regulator Valve 742793

Ewal/Parker Titan II 1/4″ Pressure Actuation Valve

Parker Veriflo Pressure Regulator Valve 45100064 SS

New Parker Veriflo Pressure Regulator 43800745 Series

Parker 71216SN2FU00 Skinner Valve Pressure Vessel

PARKER PRM2PP07LN 42 HYDRAULIC PRESSURE CONTROL VALVE

Parker MPS Convum PRESSURE Switch P6N-PG(11)

Parker sandvik high pressure hydraulic filter housing

2669 NEW Parker A4AZ Inlet Pressure Regulator

PARKER REFRIDGERANT INLET PRESSURE REGULATOR A8 A81

Parker pressure regulator 8311

PARKER PRESSURE REGULATOR

PARKER HYDRAULIC PRESSURE REDUCING VALVE ~NEW~SURPLUS~

Parker 035632000B Pressure Regulator

2 NIP NEW PARKER PRESSURE SWITCH PS1-P1091 81099

PARKER 9S HI PRESSURE SWIVEL PS1690106-16-16

PARKER 035642000B PRESSURE REGULATOR 5-125 PSIG NEW

NEW PARKER BVHP08SSS1NA HIGH PRESSURE BALL VALVE
Expedited shipping available

OILDYNE PRESSURE SWITCH PARKER 626092 NEW

PARKER PRESSURE REGULATOR 035631000B

PARKER PRESSURE REGULATOR 035642000B

Parker Veriflo SS Pressure Regulator 1/4″ 4-Port HIR103

Parker 06E21A18AC Filter Regulator Pressure Gauge

PARKER UHP VALVE…VALVE PRESSURE 150 PSI MAX.

Ewal/Parker 1/4″ Inline Needle Pressure Air/Gas Valve

PARKER 07R313AC 1/2″ 250PSI AIR PRESSURE REGULATOR

PARKER HYDRAULIC PRESSURE REDUCING VALVE ~NEW~SURPLUS~

3957 NEW Parker PR101S20 Hyd Pressure Reducer Valve

7 NEW PARKER VERIFLO PRESSURE RELIEF VALVE 110ST100

PARKER HI PRESSURE LIVE SWIVEL

Veriflo PARKER Gas / Pressure Valve Diaphragm

PARKER PRESSURE REGULATOR 5-125 PSIG

PARKER HHR1 SANDWICH PRESSURE REGULATOR W/GAUGE NEW

PARKER SCHRADER 0-60 PSIG 035600200 PRESSURE GAUGE NIB

Parker Hydraulic Pressure Filter 5W353 925580

PARKER HANNIFIN PARFLEX HIGH PRESSURE HOSE ASEMBLY

PARKER PNEUMATIC – PRESSURE REGULATOR 06R213AB 250PSI
Expedited shipping available