PLC自動控制系統可靠性問題進行了較深入研究，提出了提高系統可靠性運行的方法。實踐證明這些方法的采用對提高系統的可靠性是行之有效的。

? ? 可編程控制器由于抗干擾能力強，可靠性高，編程簡單，性能價格比高，在工業控制領域得到越來越廣泛應用。

? ? 工業年月機作為中央控制單元，配有組態軟件，選用大屏幕實時監視界面，實現各控制點的動態顯示、數據修改、故障診斷、自動報警，還可顯示查詢歷史事件記錄，系統各主要部件累計運行時間，各裝置工藝流程圖，各裝置結構圖等。中央控制單元和下位機PLC之間采用串行通訊方式進行數據交換，通常距離在1000m以內選用485雙絞線通訊方式，較常距離可選用光纖通訊，更長距離也可選用無線通訊方式。下位機選用PLC控制，根據控制對象的多少，控制對象的范圍，可選用一臺或多臺PLC進行控制，PLC之間數據交換是利用內部鏈接寄存器，實現數據交換和共享。由于PLC對現場進實時監控具有很高的可靠性，且編程簡單、靈活，因此越來越受到人們重視。

? ? 控制系統可靠性降低的主要原因

? ? 雖然工業控制機和可編程控制器本身都具有很高的可靠性，但如果輸入給PLC的開關量信號出現錯誤，模擬量信號出現較大偏差，PLC輸出口控制的執行機構沒有按要求動作，這些都可能使控制過程出錯，造成無法挽回的經濟損失。

? ? 影響現場輸入給PLC信號出錯的主要原因有：

? ? 造成傳輸信號線短路或斷路（由于機械拉扯，線路自身老化，特別是鼠害），當傳輸信號線出故障時，現場信號無法傳送給PLC，造成控制出錯；

? ? 機械觸點抖動，現場觸點雖然只閉合一次，PLC卻認為閉合了多次，雖然硬件加了濾波電路，軟件增加微分指令，但由于PLC掃描周期太短，仍可能在計數、累加、移位等指令中出錯，出現錯誤控制結果；

? ? 現場變送器，機械開關自身出故障，如觸點接觸不良，變送器反映現場非電量偏差較大或不能正常工作等，這些故障同樣會使控制系統不能正常工作。

? ? 影響執行機構出錯的主要原因有：

? ? 控制負載的接觸不能可靠動作，雖然PLC發出了動作指令，但執行機構并沒按要求動作；

? ? 控制變頻器起動，由于變頻器自身故障，變頻器所帶電機并沒按要求工作；

? ? 各種電動閥、電磁閥該開的沒能打開，該關的沒能關到位，由于執行機構沒能按PLC的控制要求動作，使系統無法正常工作，降低了系統可靠性。要提高整個控制系統的可靠性，必須提高輸入信號的可靠性和執行機構動作的準確性，否則PLC應能及時發現問題，用聲光等報警辦法提示給操作人員，盡快排除故障，讓系統安全、可靠、正確地工作。

? ? 設計完善的故障報警系統

? ? 在自動控制系統的設計中我們設計了3級故障顯示報警系統，1級設置在控制現場各控制柜面板，用指示燈指示設備正常運行和故障情況，當設備正常運行時對應指示燈亮，當該設備運行有故障時指示燈以1Hz的頻率閃爍。為防止指示燈燈泡損壞不能正確反映設備工作情況，專門設置了故障復位/燈測試按鈕，系統運行任何時間持續按該按鈕3s，所有指示燈應全部點亮，如果這時有指示等不亮說明該指示燈已壞，應立即更換，改按鈕復位后指示燈仍按原工作狀態顯示設備工作狀態。2級故障顯示設置在中心控制室大屏幕監視器上，當設備出現故障時，有文字顯示故障類型，工藝流程圖上對應的設備閃爍，歷史事件表中將記錄該故障。3級故障顯示設置在中心控制室信號箱內，當設備出現故障時，信號箱將用聲、光報警方式提示工作人員，及時處理故障。在處理故障時，又將故障進行分類，有些故障是要求系統停止運行的，但有些故障對系統工作影響不大，系統可帶故障運行，故障可在運行中排除，這樣就大大減少整個系統停止運行時間，提高系統可靠性運行水平。

? ? 輸入信號可靠性研究

? ? 要提高現場輸入給PLC信號的可靠性，首先要選擇可靠性較高的變送器和各種開關，防止各種原因引起傳送信號線短路、斷路或接觸不良。其次在程序設計時增加數字濾波程序，增加輸入信號的可信性。

? ? 在現場輸入觸點后加一定時器，定時時間根據觸點抖動情況和系統要的響應速度確定，一般在幾十ms，這樣可保證觸點確實穩定閉合后，才有其它響應。模擬信號濾波可采用圖2b程序設計方法，對現場模擬信號連續采樣3次，采樣間隔由A/D轉換速度和該模擬信號變化速率決定。3次采樣數據分別存放在數據寄存器DT10、DT11、DT12中，當最后1次采樣結束后利用數據比較、數據交換指令、數據段比較指令去掉最大和最小值，保留中間值作為本次采樣結果存放在數據寄存器DT0中。

? ? 提高讀入PLC現場信號的可靠性還可利用控制系統自身特點，利用信號之間關系來判斷信號的可信程度。如進行液位控制，由于儲罐的尺寸是已知的，進液或出液的閥門開度和壓力是已知的，在一定時間里罐內液體變化高度大約在什么范圍是知道的，如果這時液位計送給PLC的數據和估算液位高度相差較大，判斷可能是液位計故障，通過故障報警系統通知操作人員檢查該液位計。又如各儲罐有上下液位極限保護，當開關動作時發出信號給PLC，這個信號是否真實可靠，在程序設計時我們將這信號和該罐液位計信號對比，如果液位計讀數也在極限位置，說明該信號是真實的；如果液位計讀數不在極限位置，判斷可能是液位極限開關故障或傳送信號線路故障，同樣通過報警系統通知操作人員處理該故障。由于在程序設計時采用了上述方法，大大提高了輸入信號的可靠。

? ? 執行機構可靠性研究

? ? 當現場的信號準確地輸入給PLC后，PLC執行程序，將結果通過執行機構對現場裝置進行調節、控制。怎樣保證執行機構按控制要求工作，當執行機構沒有按要求工作，怎樣發現故障？我們采取以下措施：當負載由接觸器控制時，啟動或停止這類負載轉為對接觸器線圈控制，啟動時接觸器是否可靠吸合，停止時接觸器是否可靠釋放，這是我們關心的。

? ? X0為接觸器動作條件，Y0為控制線圈輸出，X1為引回到PLC輸入端的接觸器輔助常開觸點，定時器定時時間大于接觸器動作時間。R0為設定的故障位，R0為ON表示有故障，做報警處理；R0為OFF表示無故障。故障具有記憶功能，由故障復位按鈕清除。

? ? 當開啟或關閉電動閥門時，根據閥門開啟、關閉時間不同，設置延時時間，經過延時檢測開到位或關到位信號，如果這些信號不能按時準確返回給PLC，說明閥可能有故障，做閥故障報警處理。程序設計如圖3b所示。X2為閥門開啟條件，Y1為控制閥動作輸出，定時器定時時間大于閥開啟到位時間，X3為閥到位返回信號，R1為閥故障位。

? ? 我們在勝利油田勝利采油廠勝砣注聚站自動控制系統設計中采用了以上方法，經過近2年的運行證明這些方法的采用對提高系統可靠性運行是行之有效的。

GE DIFFERENTIAL RELAY 12BDD15B16A
Ref: GE DIFFERENTIAL RELAY 12BDD15B16A
GE 12-IAC66K58A Time Overcurrent Relay 12IAC66K58A New
Ref: GE 12-IAC66K58A Time Overcurrent Relay 12IAC66K58A New
GE FANUC IC3603A177-AH2 RELAY NEW IN A BOX
Ref: GE FANUC IC3603A177-AH2 RELAY NEW IN A BOX
GE General Electric 3S2791G134A1 Relay NEW Free Ship
Ref: GE General Electric 3S2791G134A1 Relay NEW Free Ship
GE Electromechanic?al Relay HEA 61V38-X2 NIB
Ref: GE Electromechanic?al Relay HEA 61V38-X2 NIB
GE MULTILIN 575 FEEDER MANAGEMENT RELAY
Ref: GE MULTILIN 575 FEEDER MANAGEMENT RELAY
GE FAULT DETECTOR RELAY 12NHC11A1A
Ref: GE FAULT DETECTOR RELAY 12NHC11A1A
NEW GE SAM RELAY 12SAM17A12A
Ref: NEW GE SAM RELAY 12SAM17A12A
GE MOTOR PROTECTION RELAY 239 250V 10A CONTACT 265VAC
Ref: GE MOTOR PROTECTION RELAY 239 250V 10A CONTACT 265VAC
NEW GE HIGH IMPEDANCE DIFFERENTIAL RELAY 12PVD21D1A
Ref: NEW GE HIGH IMPEDANCE DIFFERENTIAL RELAY 12PVD21D1A
GE 12IRT51F1A TEMPERATURE RELAY
Ref: GE 12IRT51F1A TEMPERATURE RELAY
GE IJS SYNCHRONISM-CHE?CK RELAY IJS- 52A7A New
Ref: GE IJS SYNCHRONISM-CHE?CK RELAY IJS- 52A7A New
GE TOTAL LIGHTING CONTROL 59YYY 24 RELAY DIMMING PANEL
Ref: GE TOTAL LIGHTING CONTROL 59YYY 24 RELAY DIMMING PANEL
GE 12IAV51K1A/IAV5?1K1A VOLTAGE RELAY 60CYCLE ***NIB***
Ref: GE 12IAV51K1A/IAV5?1K1A VOLTAGE RELAY 60CYCLE ***NIB***
GE Overload Relay AB252A Ic2820E500AB25A NIB 600AMP
Ref: GE Overload Relay AB252A Ic2820E500AB25A NIB 600AMP
GE STARTER WITH OVERLOAD RELAY CR305EO SIZE 3 CR324FXLS
Ref: GE STARTER WITH OVERLOAD RELAY CR305EO SIZE 3 CR324FXLS
GE VOLTAGE RELAY 12IAV54E2A *NEW*
Ref: GE VOLTAGE RELAY 12IAV54E2A *NEW*
GE Feeder Protection Relay SR 735-CASE
Ref: GE Feeder Protection Relay SR 735-CASE
GE 12IBC51M1A/IBC5?1M1A OVERCURRENT RELAY DIRECTIONL*NIB
Ref: GE 12IBC51M1A/IBC5?1M1A OVERCURRENT RELAY DIRECTIONL*NIB
1 NIB GENERAL ELECTRIC JBC53P1A JBC 53P1A DS RELAY
Ref: 1 NIB GENERAL ELECTRIC JBC53P1A JBC 53P1A DS RELAY
**NIB** GE Overload Relay RTN3F
Ref: **NIB** GE Overload Relay RTN3F
GE 124Y0E2804B Time Delay Relay 600VAC/DC NOS NEW NNB
Ref: GE 124Y0E2804B Time Delay Relay 600VAC/DC NOS NEW NNB
GE General Electric Hand reset Aux relay 12HEA11C46
Ref: GE General Electric Hand reset Aux relay 12HEA11C46
GE Multilin 565-5-5-O-A Feeder Management Relay 565B
Ref: GE Multilin 565-5-5-O-A Feeder Management Relay 565B
GE 12IAC53A803A/IA?C-53A803A OVERCURRENT RELAY **NIB**
Ref: GE 12IAC53A803A/IA?C-53A803A OVERCURRENT RELAY **NIB**
GE FANUC IC660EBR101L ELECTRIC MODULE RELAY ***RFB***
Ref: GE FANUC IC660EBR101L ELECTRIC MODULE RELAY ***RFB***
GE Time Overcurrent Relay Meter Model 12IAC51B4A, 4 EA.
Ref: GE Time Overcurrent Relay Meter Model 12IAC51B4A, 4 EA.
GE 12IFC66BD1A Long Time Overcurrent Relay IFC66BD1A
Ref: GE 12IFC66BD1A Long Time Overcurrent Relay IFC66BD1A
12XCA28A , GE RELAY TEST PLUG
Ref: 12XCA28A , GE RELAY TEST PLUG
GE MULTILIN VOLTAGE MANAGEMENT RELAY MIVII1000E00HI
Ref: GE MULTILIN VOLTAGE MANAGEMENT RELAY MIVII1000E00HI
GE 124Y0B2804A Time Delay Relay 600VAC/DC NEW NNB
Ref: GE 124Y0B2804A Time Delay Relay 600VAC/DC NEW NNB
GE TYPE HEA61 12HEA61B236X2 125VDC MULTI CONTACT RELAY
Ref: GE TYPE HEA61 12HEA61B236X2 125VDC MULTI CONTACT RELAY
GE General Electric RELAY BOARD 193X278AAG03 193X278AA
Ref: GE General Electric RELAY BOARD 193X278AAG03 193X278AA
GE 12IAC53A803A/IA?C 53A803A RELAY **NNB**
Ref: GE 12IAC53A803A/IA?C 53A803A RELAY **NNB**
GE DIFCA5B Digital Time Overcurrent Relay DIFCA5A
Ref: GE DIFCA5B Digital Time Overcurrent Relay DIFCA5A
GE 12IAC51A802A Time Overcurrent Relay IAC51A802A New
Ref: GE 12IAC51A802A Time Overcurrent Relay IAC51A802A New
GE CLO1A310T1 CONTACTOR / RT1- O/L RELAY LIQUIDATION
Ref: GE CLO1A310T1 CONTACTOR / RT1- O/L RELAY LIQUIDATION
NIB GE 3S7505BR520A5 Lamp Burnout Relay
Ref: NIB GE 3S7505BR520A5 Lamp Burnout Relay
General Electric GE 3S2791G138A4 Relay USED Free Ship
Ref: General Electric GE 3S2791G138A4 Relay USED Free Ship
General Electric GE 3S2791G138K4 Relay USED Free Ship
Ref: General Electric GE 3S2791G138K4 Relay USED Free Ship
GE SENSITIVE RELAY BOARD 193X704AAG01
Ref: GE SENSITIVE RELAY BOARD 193X704AAG01
GE TIME OVERCURRENT RELAY 12IAC53A801A *NEW*
Ref: GE TIME OVERCURRENT RELAY 12IAC53A801A *NEW*
GE DIFCA5B DIGITAL 5A TIME OVERCURRENT RELAY PROTECTION
Ref: GE DIFCA5B DIGITAL 5A TIME OVERCURRENT RELAY PROTECTION
NEW GE AUXILIARY RELAY 12HEA61C242X2
Ref: NEW GE AUXILIARY RELAY 12HEA61C242X2
GE Time Overcurrent Relay Model 12IAC51B4A IAC NEW
Ref: GE Time Overcurrent Relay Model 12IAC51B4A IAC NEW
GE Differential Voltage Relay PVD
Ref: GE Differential Voltage Relay PVD
GE Phase Directional Overcurrent Relay 12IBC53M1A
Ref: GE Phase Directional Overcurrent Relay 12IBC53M1A
$2,742.00

new rinter4848sc soft wired panel (48) ge rr7 relays
Ref: new rinter4848sc soft wired panel (48) ge rr7 relays
GE/MULTILIN 750-P5-G5-D5-HI?-A20-R FEEDER RELAY **NNB**
Ref: GE/MULTILIN 750-P5-G5-D5-HI?-A20-R FEEDER RELAY **NNB**
GE MILTINLIN 269PLUS-D/O-233?-120N-120 MOTOR MGR RELAY
Ref: GE MILTINLIN 269PLUS-D/O-233?-120N-120 MOTOR MGR RELAY
GE Over Current Relay MIFPA55E100H00C 50/60 Hz (NIB)
Ref: GE Over Current Relay MIFPA55E100H00C 50/60 Hz (NIB)
GE MULTILIN SR735 SR735-5-5-HI-48?5 FEEDER RELAY
Ref: GE MULTILIN SR735 SR735-5-5-HI-48?5 FEEDER RELAY
GE Multilin Motor Management Relay 269 PLUS
Ref: GE Multilin Motor Management Relay 269 PLUS
GE/MULTILIN 369-HI-R-M-0-0 MOTOR RELAY *XLNT*
Ref: GE/MULTILIN 369-HI-R-M-0-0 MOTOR RELAY *XLNT*
GE Feeder Protection Relay DFP200 DFP251MHE1BB02 w/o ct
Ref: GE Feeder Protection Relay DFP200 DFP251MHE1BB02 w/o ct
GE Reveal Under Frequency Meter Relay 12SFF31A1A NIB
Ref: GE Reveal Under Frequency Meter Relay 12SFF31A1A NIB
GE MULTILIN 750 PROTECTIVE RELAY 750-P5-G5-D5-HI?-A2-OR
Ref: GE MULTILIN 750 PROTECTIVE RELAY 750-P5-G5-D5-HI?-A2-OR
GE GENERAL ELECTRIC 239-H MOTOR PROTECTION RELAY 1/2HP
Ref: GE GENERAL ELECTRIC 239-H MOTOR PROTECTION RELAY 1/2HP
GE GENERAL ELECTRIC IC3655A100A SLIP GUARD RELAY MODULE
Ref: GE GENERAL ELECTRIC IC3655A100A SLIP GUARD RELAY MODULE
GE 750-P5-G5-S5-HI?-A20-R SR750 Feeder Management Relay
Ref: GE 750-P5-G5-S5-HI?-A20-R SR750 Feeder Management Relay
GE 750-P5-G5-S5-HI?-A20-R SR750 Feeder Management Relay
Ref: GE 750-P5-G5-S5-HI?-A20-R SR750 Feeder Management Relay
GE High impedance Differential relay type PVD 21D1A
Ref: GE High impedance Differential relay type PVD 21D1A
GE Type HFA Auxiliary Relay SR768574 115V 50Hz (NIB)
Ref: GE Type HFA Auxiliary Relay SR768574 115V 50Hz (NIB)
GE Voltage Relay Mod #TOV5013B110H00?C (NIB)
Ref: GE Voltage Relay Mod #TOV5013B110H00?C (NIB)
GE Multilin 750 Feeder Protection Management Relay Unit
Ref: GE Multilin 750 Feeder Protection Management Relay Unit
NEW GE STATIC FREQUENCY RELAY 12SFF31A1A
Ref: NEW GE STATIC FREQUENCY RELAY 12SFF31A1A
169PLUS-10C-120 Ge Multilin Motor Mgt. Relay
Ref: 169PLUS-10C-120 Ge Multilin Motor Mgt. Relay
NEW GE DIFFERENTIAL RELAY 12BDD19B1A VOLT 125 – 250 VDC
Ref: NEW GE DIFFERENTIAL RELAY 12BDD19B1A VOLT 125 – 250 VDC
GE 735-5-5-HI-485 SR735 Feeder Protection Relay
Ref: GE 735-5-5-HI-485 SR735 Feeder Protection Relay
NEW GE TYPE BDD DIFFERENTIAL RELAY 12BDD16B1A
Ref: NEW GE TYPE BDD DIFFERENTIAL RELAY 12BDD16B1A
GE MDP3120000DA Time Overcurrent Relay MDP 3120000DA
Ref: GE MDP3120000DA Time Overcurrent Relay MDP 3120000DA
GE PC Board 269PLUS-120N120 Motor Relay PC Card (3249)
Ref: GE PC Board 269PLUS-120N120 Motor Relay PC Card (3249)
GE Multilin 735 Feeder Protection Relay Unit
Ref: GE Multilin 735 Feeder Protection Relay Unit
NEW GE FANUC IC655MDL581A OUTPUT MODULE RELAY 32PT
Ref: NEW GE FANUC IC655MDL581A OUTPUT MODULE RELAY 32PT
GE Multilin HAA Auxiliary Annunciator Relay HAA13B1A DC
Ref: GE Multilin HAA Auxiliary Annunciator Relay HAA13B1A DC
GE Drive Terminal Relay Card 531X171TMAAFG2 NIB
Ref: GE Drive Terminal Relay Card 531X171TMAAFG2 NIB
GE 369-HI-R-M-F-0 MULTILIN MOTOR MANAGEMENT RELAY
Ref: GE 369-HI-R-M-F-0 MULTILIN MOTOR MANAGEMENT RELAY
NEW GE MULTILIN VOLTAGE MANAGEMENT RELAY 2 PACK MIVII
Ref: NEW GE MULTILIN VOLTAGE MANAGEMENT RELAY 2 PACK MIVII
GE LIGHTING CONTROLS RINTER2424 24 RELAY PANEL INTERIOR
Ref: GE LIGHTING CONTROLS RINTER2424 24 RELAY PANEL INTERIOR
NEW GE ELECTRIC MULTILIN MOTOR PROTECTION RELAY 122 NR
Ref: NEW GE ELECTRIC MULTILIN MOTOR PROTECTION RELAY 122 NR
GE 239 Motor protection Relay “NIB”
Ref: GE 239 Motor protection Relay “NIB”
GE General Electric 750 Feeder Management Relay 750-P5
Ref: GE General Electric 750 Feeder Management Relay 750-P5
GE Fanuc IC660BBR100N GENIUS NC RELAY BLOCK 115/230VAC
Ref: GE Fanuc IC660BBR100N GENIUS NC RELAY BLOCK 115/230VAC
GE Differential Relay Model 12STD15C3A – New Old Stock
Ref: GE Differential Relay Model 12STD15C3A – New Old Stock
NEW GE IC3600 RELAY DRIVER IC3600LRDH1B1D IC3600LRDH1
Ref: NEW GE IC3600 RELAY DRIVER IC3600LRDH1B1D IC3600LRDH1
GE Drive Relay Board 193X562ACG06 NIB
Ref: GE Drive Relay Board 193X562ACG06 NIB
GE Restraint Relay IFCV-TOC IFCV51AD1A NIB
Ref: GE Restraint Relay IFCV-TOC IFCV51AD1A NIB
GE Solid State Ground Break Relay, TGMR1D, NIB
Ref: GE Solid State Ground Break Relay, TGMR1D, NIB
GE TIME OVERCURRENT RELAY 12SFC151D1A
Ref: GE TIME OVERCURRENT RELAY 12SFC151D1A
GE 12CFV12A4A NEW POLYPHASE UNDERVOLTAGE RELAY
Ref: GE 12CFV12A4A NEW POLYPHASE UNDERVOLTAGE RELAY
GE RELAY CIRCUIT BOARD 193X703ADG04
Ref: GE RELAY CIRCUIT BOARD 193X703ADG04
GE Undervoltage Relay Type NGV 12NGV15A22 208V
Ref: GE Undervoltage Relay Type NGV 12NGV15A22 208V
GE IJS 52D1A Synchronism Check Relay IJS52D1A
Ref: GE IJS 52D1A Synchronism Check Relay IJS52D1A
$296.00
GE Transformer Overcurrent Relay TOC7102B201C10 MSI129
Ref: GE Transformer Overcurrent Relay TOC7102B201C10 MSI129
GE 12IFC53B1A Inverse Time Overcurrent Relay IFC53B1A
Ref: GE 12IFC53B1A Inverse Time Overcurrent Relay IFC53B1A
GE 12IFC53A2A Inverse Time Overcurrent Relay IFC53A2A
Ref: GE 12IFC53A2A Inverse Time Overcurrent Relay IFC53A2A
NIB GE STATIC BREAKER BACK-UP RELAY 3661034CFR SBC 10 A
Ref: NIB GE STATIC BREAKER BACK-UP RELAY 3661034CFR SBC 10 A
12XLA12A1 , GE RELAY TEST PLUG
Ref: 12XLA12A1 , GE RELAY TEST PLUG
GE- NIB Photoelectric Relay Model #3S7505KP501A1
Ref: GE- NIB Photoelectric Relay Model #3S7505KP501A1
NEW General Electric GE Relay Test Plug 12XLA12A1 NR!
Ref: NEW General Electric GE Relay Test Plug 12XLA12A1 NR!
GE INFOGRAPHICS RRM16-E1L 16 OUTPUT RELAYS NEW IN BOX
Ref: GE INFOGRAPHICS RRM16-E1L 16 OUTPUT RELAYS NEW IN BOX
GE GENERAL ELECTRIC 12IAC66C56A TIME OVERCURRENT RELAY
Ref: GE GENERAL ELECTRIC 12IAC66C56A TIME OVERCURRENT RELAY
(10) GE Overload Relays
Ref: (10) GE Overload Relays
GE IAC 53A803A Time-Overcurren?t Relay NEW NIB
Ref: GE IAC 53A803A Time-Overcurren?t Relay NEW NIB
GE Auxiliary Relay HAA 15H2F NIB
Ref: GE Auxiliary Relay HAA 15H2F NIB
GE IAC 51B808A Time-Overcurren?t Relay NEW NIB
Ref: GE IAC 51B808A Time-Overcurren?t Relay NEW NIB
GE 12HFC21B1A Instantaneous Overcurrent Relay HFC21B1A
Ref: GE 12HFC21B1A Instantaneous Overcurrent Relay HFC21B1A
GE General Electric DC Contactor Relay 150 DC Amps 600V
Ref: GE General Electric DC Contactor Relay 150 DC Amps 600V
NEW GE AUXILIARY RELAY 12HFA54E187F
Ref: NEW GE AUXILIARY RELAY 12HFA54E187F
GE INFOGRAPHICS RIM16-E1L 16 INPUT RELAYS NEW IN BOX
Ref: GE INFOGRAPHICS RIM16-E1L 16 INPUT RELAYS NEW IN BOX
GE FANUC OUTPUT RELAY PLUG-IN MODULE MODEL IC610MDL182A
Ref: GE FANUC OUTPUT RELAY PLUG-IN MODULE MODEL IC610MDL182A
NEW GE AUXILIARY RELAY 12HFA51A42H
Ref: NEW GE AUXILIARY RELAY 12HFA51A42H
GE CASI RUSCO 110078001 MICRO/5 16DOR 16 RELAYS 16DO
Ref: GE CASI RUSCO 110078001 MICRO/5 16DOR 16 RELAYS 16DO
GE Fanuc IC-697-MDL-653/?IC697MDL653 Input Relay
Ref: GE Fanuc IC-697-MDL-653/?IC697MDL653 Input Relay
GE Transformer Overcurrent Relay TOC7102B201C00 MSI129
Ref: GE Transformer Overcurrent Relay TOC7102B201C00 MSI129
NEW GE Fanuc 16 Circuit Relay Output Module IC610MDL182
Ref: NEW GE Fanuc 16 Circuit Relay Output Module IC610MDL182
GE CR2810A14AG102 10A 600V 8 N.O. P Machine Tool Relay
Ref: GE CR2810A14AG102 10A 600V 8 N.O. P Machine Tool Relay
GE RTN3E Manual Reset Overload Relay CK75C-CK08C NEW
Ref: GE RTN3E Manual Reset Overload Relay CK75C-CK08C NEW
GE Contactor CL03-45 CL45A Reversing relay 480v NEW
Ref: GE Contactor CL03-45 CL45A Reversing relay 480v NEW
GE FANUC IC200MDD845C MIXED OUT RELAY 8PT IN 16 PT NEW
Ref: GE FANUC IC200MDD845C MIXED OUT RELAY 8PT IN 16 PT NEW
GE Auxiliary Relay Model 12HFA51A42H Type HFA
Ref: GE Auxiliary Relay Model 12HFA51A42H Type HFA
NEW GE 12HFA51A49F, HFA MULTICONTACT AUXILIARY RELAY
Ref: NEW GE 12HFA51A49F, HFA MULTICONTACT AUXILIARY RELAY
NEW GE Relay 12HFA151A5F Type HFA 24 Volts DC
Ref: NEW GE Relay 12HFA151A5F Type HFA 24 Volts DC
CR120K60041AA GE RELAY, HIGH FIDELITY
Ref: CR120K60041AA GE RELAY, HIGH FIDELITY
SQUARE D AC RELAY OPERATED TIMER # 8501-G040GE
Ref: SQUARE D AC RELAY OPERATED TIMER # 8501-G040GE
GE CR324FXMS SIZE 3/4 SOLID STATE OVERLOAD RELAY NEW
Ref: GE CR324FXMS SIZE 3/4 SOLID STATE OVERLOAD RELAY NEW
GE Fanuc IC610MDL182A Relay Output Module
Ref: GE Fanuc IC610MDL182A Relay Output Module
GE Fanuc IC610MDL180A Relay Output Module
Ref: GE Fanuc IC610MDL180A Relay Output Module
GE Fanuc IC610MDL104A DC Input/Relay Output Module
Ref: GE Fanuc IC610MDL104A DC Input/Relay Output Module
GE GENERAL ELECTRIC RELAY TESTER MODEL 12LA12A1 “NEW”
Ref: GE GENERAL ELECTRIC RELAY TESTER MODEL 12LA12A1 “NEW”
GE TIME 12IAC51B808A OVERCURRENT RELAY 2-16A, 20-160A
Ref: GE TIME 12IAC51B808A OVERCURRENT RELAY 2-16A, 20-160A
GE SIZE 3/4 SOLID STATE OVERLOAD RELAY NEW CR324FXLS
Ref: GE SIZE 3/4 SOLID STATE OVERLOAD RELAY NEW CR324FXLS
NEW GE TIME OVERCURRENT RELAY 12IAC53M101A
Ref: NEW GE TIME OVERCURRENT RELAY 12IAC53M101A
NEW GE INSTANTANEOUS CURRENT RELAY 12PJC11AV1A
Ref: NEW GE INSTANTANEOUS CURRENT RELAY 12PJC11AV1A
NEW GE TIME OVERCURRENT RELAY 12IAC66B1A
Ref: NEW GE TIME OVERCURRENT RELAY 12IAC66B1A
GE MULTILIN 369 MOTOR PROTECTION MANAGEMENT RELAY
Ref: GE MULTILIN 369 MOTOR PROTECTION MANAGEMENT RELAY
GE INFOGRAPHICS RIM16-E00 16 INPUT RELAYS NEW IN BOX
Ref: GE INFOGRAPHICS RIM16-E00 16 INPUT RELAYS NEW IN BOX
VINTAGE- GE PYROMETER 0-2000F TYPE 195 METER RELAY NEW
Ref: VINTAGE- GE PYROMETER 0-2000F TYPE 195 METER RELAY NEW
GE Fanuc Series One relay output IC610MDL182A NEW
Ref: GE Fanuc Series One relay output IC610MDL182A NEW
GE PLC I/O Module DC In/ 8-Relay Out IC610MDL104A
Ref: GE PLC I/O Module DC In/ 8-Relay Out IC610MDL104A
GE GENERAL ELECTRIC HFA51 RELAY HFA51A42H HFA NEW
Ref: GE GENERAL ELECTRIC HFA51 RELAY HFA51A42H HFA NEW
$199.95
GE CR324E310F OVERLOAD RELAY 90A 3 POLE 600VAC 250VDC
Ref: GE CR324E310F OVERLOAD RELAY 90A 3 POLE 600VAC 250VDC
NEW GE Relay Model 12HFA51A49H HFA 115V GEF-2757E
Ref: NEW GE Relay Model 12HFA51A49H HFA 115V GEF-2757E
GE/MULTILIN 130 MOTOR PROTECTION RELAY *XLNT*
Ref: GE/MULTILIN 130 MOTOR PROTECTION RELAY *XLNT*
GE 531X137TRGACG1 TB RELAY BOARD ***XLNT***
Ref: GE 531X137TRGACG1 TB RELAY BOARD ***XLNT***
GE IC300DQM902B IC 300 DQM 902 B 20 Point Relay Output
Ref: GE IC300DQM902B IC 300 DQM 902 B 20 Point Relay Output
GE Fanuc 90/30 IC693MDL940E Relay N.O. Output Module
Ref: GE Fanuc 90/30 IC693MDL940E Relay N.O. Output Module
Brand new GE oven ERC/LWR oven relay part # WB27T10971
Ref: Brand new GE oven ERC/LWR oven relay part # WB27T10971
SQUARE D AC RELAY OPERATED TIMER G0-40-GE CLASS 8501
Ref: SQUARE D AC RELAY OPERATED TIMER G0-40-GE CLASS 8501
NIB GE PILOT WIRE AUX RELAY 12NAA99AM1A 125 VDC
Ref: NIB GE PILOT WIRE AUX RELAY 12NAA99AM1A 125 VDC
New Sealed GE FANUC IC693MDL930G 4A 8PT OUTPUT RELAY
Ref: New Sealed GE FANUC IC693MDL930G 4A 8PT OUTPUT RELAY
NIB GE AUXILIARY RELAY 12HFA151A1F TYPE HFA 250 V
Ref: NIB GE AUXILIARY RELAY 12HFA151A1F TYPE HFA 250 V
GE CR120BL060 600V Latched Relay CR120-L-060 NNB
Ref: GE CR120BL060 600V Latched Relay CR120-L-060 NNB
GE General Electric Relay Model 12H6A11B2 125 VDC
Ref: GE General Electric Relay Model 12H6A11B2 125 VDC
GE Fanuc IDEC IZBARL IBRC410 IBRC 410 RELAY BARRIER
Ref: GE Fanuc IDEC IZBARL IBRC410 IBRC 410 RELAY BARRIER
GE 12HFA51A42/HFA-?51A42 AUXILIARY RELAY ***NIB***
Ref: GE 12HFA51A42/HFA-?51A42 AUXILIARY RELAY ***NIB***
GE PNEUMATIC TIME DELAY RELAY CR2820B110AA2 115V NEW
Ref: GE PNEUMATIC TIME DELAY RELAY CR2820B110AA2 115V NEW
GE CR324FXMS SIZE 3/4 SOLID STATE OVERLOAD RELAY NEW
Ref: GE CR324FXMS SIZE 3/4 SOLID STATE OVERLOAD RELAY NEW
NEW – Electromate Electrical Relay Box w/3 GE Relays
Ref: NEW – Electromate Electrical Relay Box w/3 GE Relays
GE 3S7511RS575A6 Resistive sensitive relay NEW NIB
Ref: GE 3S7511RS575A6 Resistive sensitive relay NEW NIB
GE CR2820B420AA42 Pneumatic Time Delay Relay NEW NIB
Ref: GE CR2820B420AA42 Pneumatic Time Delay Relay NEW NIB
New GE Fanuc IC693MDL930F Output Relay Module *Sealed*
Ref: New GE Fanuc IC693MDL930F Output Relay Module *Sealed*
GE CR120B01502 Industrial Relay, NOS
Ref: GE CR120B01502 Industrial Relay, NOS
GE FANUC IC697MDL940 OUTPUT RELAY MODULE 120VAC 16PT
Ref: GE FANUC IC697MDL940 OUTPUT RELAY MODULE 120VAC 16PT
GE CR2820B-110AA2 Pneumatic Time Delay Relay New CR2820
Ref: GE CR2820B-110AA2 Pneumatic Time Delay Relay New CR2820
GE FANUC IC693MDL940H OUTPUT MODULE RELAY 2AMP 16POINT
Ref: GE FANUC IC693MDL940H OUTPUT MODULE RELAY 2AMP 16POINT
GE 12HGA17C52/HGA1?7C52 AUXILIARY RELAY ***NIB***
Ref: GE 12HGA17C52/HGA1?7C52 AUXILIARY RELAY ***NIB***
NIB GE RELAY HFA 12HFA51A49F
Ref: NIB GE RELAY HFA 12HFA51A49F
GE Time Overcurrent Relay Type IAC Model 12IAC51B4A New
Ref: GE Time Overcurrent Relay Type IAC Model 12IAC51B4A New
GE FANUC IC693MDL940E OUTPUT MODULE RELAY 2A 16PT
Ref: GE FANUC IC693MDL940E OUTPUT MODULE RELAY 2A 16PT
GE Fanuc Series 90 Micro IC693UDR005CP1 24VDC In Relay
Ref: GE Fanuc Series 90 Micro IC693UDR005CP1 24VDC In Relay
GE CR324HXTS SIZE 6 SOLID STATE OVERLOAD RELAY NEW
Ref: GE CR324HXTS SIZE 6 SOLID STATE OVERLOAD RELAY NEW
UNUSED GE VOLTAGE RELAY 12IAV51A1AF
Ref: UNUSED GE VOLTAGE RELAY 12IAV51A1AF
GE 115 V 60 AMP AUXILIARY RELAY MODEL 12HGA11J70
Ref: GE 115 V 60 AMP AUXILIARY RELAY MODEL 12HGA11J70
GE General Electric RTN3B Overload Relay 55-80a amp NEW
Ref: GE General Electric RTN3B Overload Relay 55-80a amp NEW
GE General Electric RTN3B Overload Relay 55-80a amp NEW
Ref: GE General Electric RTN3B Overload Relay 55-80a amp NEW
**NIB** GE Electronic Relay RMM2AR
Ref: **NIB** GE Electronic Relay RMM2AR
RRDC12 GE RELAY DRIVER BOARD
Ref: RRDC12 GE RELAY DRIVER BOARD
GE IC610MDL180A Relay Output Module 8-Channel
Ref: GE IC610MDL180A Relay Output Module 8-Channel
NEW GE PHASE SEQUENCE & UNDERVOLTAGE RELAY 12ICR54A1A
Ref: NEW GE PHASE SEQUENCE & UNDERVOLTAGE RELAY 12ICR54A1A
(5) NEW GE Federal Pacif Relay Breaker 12HFA51A49H $149
Ref: (5) NEW GE Federal Pacif Relay Breaker 12HFA51A49H $149
10 NEW GE OVERLOAD RELAY CR4G2WYY2+CR4XG?6 23-30 Free S.
Ref: 10 NEW GE OVERLOAD RELAY CR4G2WYY2+CR4XG?6 23-30 Free S.
GE 90-30 IC693MDL940H OUTPUT PLC MODULE RELAY 2A 16pt
Ref: GE 90-30 IC693MDL940H OUTPUT PLC MODULE RELAY 2A 16pt
GE Smart Relay Block SRBA120A10A 10A 120V NEW IN BOX
Ref: GE Smart Relay Block SRBA120A10A 10A 120V NEW IN BOX
GE Overload Relay CR324C310A Manual Reset Only
Ref: GE Overload Relay CR324C310A Manual Reset Only
GE CR122A04702AA Pneumatic Time Delay Relay NEW
Ref: GE CR122A04702AA Pneumatic Time Delay Relay NEW
GE CR120A02202AA 300V Relay NEW
Ref: GE CR120A02202AA 300V Relay NEW
General Electric GE HFA relay 12HFA51A42F
Ref: General Electric GE HFA relay 12HFA51A42F
GE FANUC IC693MDL940C OUTPUT RELAY MODULE ****XLNT****
Ref: GE FANUC IC693MDL940C OUTPUT RELAY MODULE ****XLNT****
$149.00
NIB GE AUXILIARY RELAY 12HGA111A1F HGA 250 V
Ref: NIB GE AUXILIARY RELAY 12HGA111A1F HGA 250 V
GE FANUC IC693MDL940F OUTPUT RELAY MODULE ****XLNT****
Ref: GE FANUC IC693MDL940F OUTPUT RELAY MODULE ****XLNT****
GE 10 PIN RELAY CR245C111A
Ref: GE 10 PIN RELAY CR245C111A
New GE Automation Panel Relay Driver Card, RRDC1
Ref: New GE Automation Panel Relay Driver Card, RRDC1
GE CR124Y0A2829A RELAY 5A 600VAC CR124Y-0A2829A NEW
Ref: GE CR124Y0A2829A RELAY 5A 600VAC CR124Y-0A2829A NEW
GE General Electric GE IAC 51B806A Industrial Relay
Ref: GE General Electric GE IAC 51B806A Industrial Relay
NEW GE Fanuc 8 Circuit Relay Output Module IC610MDL180A
Ref: NEW GE Fanuc 8 Circuit Relay Output Module IC610MDL180A
GE CR120BD03241 Industrial Relay 125VDC Coil 10A 600V
Ref: GE CR120BD03241 Industrial Relay 125VDC Coil 10A 600V
GE FANUC IC693MDL940G OUTPUT RELAY MODULE ****XLNT****
Ref: GE FANUC IC693MDL940G OUTPUT RELAY MODULE ****XLNT****
GE Fanuc PLC Relay Output Module IC693MDL940G
Ref: GE Fanuc PLC Relay Output Module IC693MDL940G
BF914K GE FANUC PLC Card Relay Out Module
Ref: BF914K GE FANUC PLC Card Relay Out Module
Fanuc (GE) #IC610-MDL180A Relay Output 8 Cir (U) 5/5/43
Ref: Fanuc (GE) #IC610-MDL180A Relay Output 8 Cir (U) 5/5/43
GE CR324DXHS SIZE 2 SOLID STATE OVERLOAD RELAY NEW
Ref: GE CR324DXHS SIZE 2 SOLID STATE OVERLOAD RELAY NEW
GE CR324DXJS SIZE 2 SOLID STATE OVERLOAD RELAY NEW
Ref: GE CR324DXJS SIZE 2 SOLID STATE OVERLOAD RELAY NEW
GE FANUC MIXED I/O MODULE 24 VDC, IN=RELAY OUT=8 PT NEW
Ref: GE FANUC MIXED I/O MODULE 24 VDC, IN=RELAY OUT=8 PT NEW
GE FANUC IC610MDL182A Relay Output Model 16 ! NEW !
Ref: GE FANUC IC610MDL182A Relay Output Model 16 ! NEW !
GE FANUC OUTPUT MODULE RELAY 16-POINT IC693MDL940C
Ref: GE FANUC OUTPUT MODULE RELAY 16-POINT IC693MDL940C
GE Fanuc IC693MDL940C Output Relay Module
Ref: GE Fanuc IC693MDL940C Output Relay Module
GE Power Board Relay Power Supply WB23T10023 NEW
Ref: GE Power Board Relay Power Supply WB23T10023 NEW
GE IC610MDL180A 24VDC RELAY OUTPUT MDL/8 I/O MODULE
Ref: GE IC610MDL180A 24VDC RELAY OUTPUT MDL/8 I/O MODULE
GE FANUC IC693MDL940A OUTPUT RELAY MODULE ****XLNT****
Ref: GE FANUC IC693MDL940A OUTPUT RELAY MODULE ****XLNT****
NEW GE AUXILIARY RELAY 12HEA61ARU226X2 125V
Ref: NEW GE AUXILIARY RELAY 12HEA61ARU226X2 125V
GE FANUC IC660TBR101K TERMINAL ASSEMBLY RELAY ***RFB***
Ref: GE FANUC IC660TBR101K TERMINAL ASSEMBLY RELAY ***RFB***
GE Range Power Relay Board WB23T10024
Ref: GE Range Power Relay Board WB23T10024
GE General Electric Relay CR120A04002AA NEW
Ref: GE General Electric Relay CR120A04002AA NEW
GE CONTROL NEMA 4 TIME DELAY UNDERVOLTAGE RELAY NIB
Ref: GE CONTROL NEMA 4 TIME DELAY UNDERVOLTAGE RELAY NIB
GE 4PDT 2.0 AMP 26.5V DC MIL SPEC SEALED RELAY
Ref: GE 4PDT 2.0 AMP 26.5V DC MIL SPEC SEALED RELAY
New GE Fanuc IC693MDL930 8 Pt. Iso. Relay Out 90-30 NIB
Ref: New GE Fanuc IC693MDL930 8 Pt. Iso. Relay Out 90-30 NIB
GE Time Overcurrent Relay Model 12IAC51B4R IAC
Ref: GE Time Overcurrent Relay Model 12IAC51B4R IAC
GE CR324CXFS SIZE 0/1 SOLID STATE OVERLOAD RELAY NEW
Ref: GE CR324CXFS SIZE 0/1 SOLID STATE OVERLOAD RELAY NEW
(2) GE Overload Relay Manual Resets
Ref: (2) GE Overload Relay Manual Resets
GE Funac 90-30 Output Relay, P/N: IC693MDL940D, 16 Pt
Ref: GE Funac 90-30 Output Relay, P/N: IC693MDL940D, 16 Pt
NEW CR120C24802 GE INDUSTRIAL RELAY 300V 10A 120V 8P
Ref: NEW CR120C24802 GE INDUSTRIAL RELAY 300V 10A 120V 8P
GE FANUC IC693MDL940C OUTPUT RELAY MODULE ****XLNT****
Ref: GE FANUC IC693MDL940C OUTPUT RELAY MODULE ****XLNT****
GE 120B-080** 600V INDUSTRIAL RELAY ***NNB***
Ref: GE 120B-080** 600V INDUSTRIAL RELAY ***NNB***
GE SMART RELAY LOADER PART NO. SRLA
Ref: GE SMART RELAY LOADER PART NO. SRLA
GE CR324CXES SIZE 0/1 SOLID STATE OVERLOAD RELAY NEW
Ref: GE CR324CXES SIZE 0/1 SOLID STATE OVERLOAD RELAY NEW
GE CR324CXHS SIZE 0/1 SOLID STATE OVERLOAD RELAY NEW
Ref: GE CR324CXHS SIZE 0/1 SOLID STATE OVERLOAD RELAY NEW
GE CR324CXCS SIZE 6 SOLID STATE OVERLOAD RELAY NEW
Ref: GE CR324CXCS SIZE 6 SOLID STATE OVERLOAD RELAY NEW
GE CR324CXDS SIZE 0/1 SOLID STATE OVERLOAD RELAY NEW
Ref: GE CR324CXDS SIZE 0/1 SOLID STATE OVERLOAD RELAY NEW
GE CR224C310A Overload Relay 3 Leg Block
Ref: GE CR224C310A Overload Relay 3 Leg Block
GE Relay Drive Card
Ref: GE Relay Drive Card
GE SMART RELAY BLOCK SRBA024D10A INPUT SIGNAL 24VDC
Ref: GE SMART RELAY BLOCK SRBA024D10A INPUT SIGNAL 24VDC
GE CR122B040120A Pneumatic Timer Relay 0.2-60s NEW NNB
Ref: GE CR122B040120A Pneumatic Timer Relay 0.2-60s NEW NNB
GE Fanuc IC630MDL380A Relay Output Module 16 Circuits
Ref: GE Fanuc IC630MDL380A Relay Output Module 16 Circuits
4 GE Overload Manual Reset Relay # CR324C310F; *A12
Ref: 4 GE Overload Manual Reset Relay # CR324C310F; *A12
GE Fanuc IC693MDL940D Output Module Relay #7090
Ref: GE Fanuc IC693MDL940D Output Module Relay #7090
GE CR120A08022AA, 300V Relay, Series A, NOS